(at around 42 mins) When they take over the stock exchange, the bad guys enter the place shooting. It is noticeable that their machine guns are not shooting and yet we hear the noise and we see the ricochet of the bullets against the monitors in the ceiling.
(at around 2 mins) When on the plane the CIA Op, attempting to get information out of Bane's men, fires a handgun near the head of one of the men; however, the slide on the automatic does not move despite the sound of the gun firing, nor is a spent shell seen ejecting from the gun.
(at around 34 mins) When Bruce Wayne is at the ball with Selina Kyle, he corrects her pronunciation of Ibiza to "Eye-beeth-a". Although it's pronounced that way by many English speakers, strictly it's pronounced "Ee-beeth-a".
(at around 16 mins) When Bruce Wayne checks his computer in the bat cave and looks at the files he has on Seline Kyle, there is an Incident Report by the Gotham Police Department. On the top, it says "Klye, Selina", instead of "Kyle, Selina".
(at around 44 mins) In the stock market scene, Bane's henchman that has the tablet that is downloading information is seen putting it in his bag. In the next shot he can be seen doing this again even though the tablet was already put in the bag.
(at around 44 mins) The stock market exchange scene takes place during daylight. They established less than 10 minutes were needed to complete the exchange fiasco. Yet, when it's completed, its already night time.
(at around 2 mins) In the opening plane sequence, the main CIA operative fires a gun right by one of the prisoners' head out the plane door. His gun does not recoil from the shot, but a gun shot is heard. Later, we see him recock the hammer, an action that would have been unnecessary if the gun had actually been fired.
(at around 56 mins) Throughout the trilogy, Batman noticeably wears thick black make up around his eyes when he has his mask on. However, when he returns The Bat to the cave for the first time, he talks with Alfred without his mask on, yet there is no sign of any make-up.
(at around 11 mins) When Bruce shoots the arrow at the target and startles Selena, it clearly hits right on the number 7 on the target. A moment later from Bruce's perspective, the arrow is in the target a full 6 inches to the right of the number 7.
(at around 44 mins) After Bane and his men attack the stock exchange, vehicle crash barriers are deployed on the streets. The one we see deploying has its open side towards the stock exchange. But when Bane and his men leave on their motorcycles, the open sides of the angled crash barriers are pointed away from the exchange allowing Bane to use them as ramps.
(at around 48 mins) During the chase following the stock market robbery, the television headline alternates between "RETURN OF THE BATMAN?" and "THE RETURN OF THE BATMAN?" (with the "the" appearing and disappearing between different shots of televisions.)
During the scenes at Wayne Manor (which was filmed at Wollaton Hall in Nottingham, UK) we see that the building is made of limestone. Yet during several scenes in the interior of the building, red bricks can be seen outside the windows, showing that the interior scenes were obviously shot at a different location or in a studio.
(at around 15 mins) In Selina Kyle's first mugshot she is little over 66 inches (about 5'7") according to the height chart. In her second mugshot she is shown to be almost 72 inches (almost 6 feet tall).
(at around 2h 10 mins) As Batman begins to approach Bane just before their final confrontation, the same extra (a middle-aged gray-beard in a brown vest) can be seen fighting behind Batman only to be seen fighting behind Bane a split second later.
(at around 2h 15 mins) When Batman and Bane are fighting on the top step of the Town Hall, Bane charges at Batman and punches the column with such force that part of the column crumbles off. In the next shot from behind Batman, the column is back to normal.
(at around 2h 25 mins) When the truck that carries the bomb is forced to crash the railing and fall down to the road below, we see no light pole. But in the next scene, we see a light pole knocked over by the truck as it falls.
(at around 2h 25 mins) During the final Gotham street chase between the Tumblers and the Bat, just before the missile hits one of the Tumblers, we see the Bat fly in one direction and the next shot in the opposite direction.
(at around 56 mins) When Bruce is speaking to Alfred while sitting at a computer in the cave after he returns from rescuing Selina Kyle, his hair is lying unkempt over his left eye. However, when the camera moves to show Alfred and returns almost immediately to Bruce, his hair is neatly slicked back over his eyes.
(at around 23 mins) Following the scene where Bane's sniper goes into the sewer and Commissioner Gordon gives chase, there is an explosion. The blast comes up through the manhole and the cop (on the left) clearly has flame retardant jelly covering his face.
(at around 1h 35 mins) When Bane is reading the letter written by Gordon, there is a light skin-tone colored microphone wire leading down the back of his neck. It continues to protrude repeatedly, especially when he turns his head to his left.
(at around 1h 30 mins) In the football stadium when Bane grabs the microphone off the Official, it is the back judge who would not have a microphone - only the head referee would have a microphone. Further, it's not a regular microphone, it's a headset used for communications between coaches, and between the booth official(s) and field officials. Those systems aren't connected to the PA system, though it can be done if a need comes up. Obviously Bane wasn't coordinating with the PA control booth, he just picks up the headset and talks in to the mic part as if it were hooked in already.
(at around 1h 30 mins) When the bad guys are taking over Gotham, there are a number of bridges blown up. Some are suspension bridges that eventually have a small section of the center of the span blown away. A simple understanding of engineering would prove that stability is absolutely dependent upon the tension of the suspending ropes that stretch over the tops of the supporting towers. Yet, these bridges still seem to dangle out far beyond the towers with nothing to hold them up. With the cables cut, everything beyond the tower should have fallen immediately.
(at around 2 mins) The soldiers assisting in the pickup of Dr. Pavel are elite Delta Force operators, as evidenced by the distinctive USASOC patch and Airborne tab worn on their uniform. However, they make numerous tactical mistakes when the plane comes under attack. When Bane's henchmen begin shooting through the plane windows, the supposedly highly trained soldiers are bewildered, and make no move to engage them or take cover, allowing themselves to be gunned down. Meanwhile, two others ignore the attack and instead physically assault the restrained henchmen. Additionally, when the plane is tilted to vertical, one of the soldiers who falls to the rear struggles for several seconds to unholster his weapon- something no soldier would do, let alone a highly trained Delta Force operator.
The idea of converting a fusion reactor to a bomb is stupid. This is an inherent characteristic of such systems. Fusion can only be sustained under containment, and, any loss of containment would cause the plasma to cool co fast that fusion would cease in microseconds. As for turning the "core" into a portable bomb, this is even more implausible. Without external power, there could be no containment field, nor any fuel injection. The entire plot point is physically impossible, not merely "rubber science."
(at around 1h 35 mins) Throughout the movie, Blake is seen carrying a Glock 17 pistol. When Gordon and Blake are talking in the apartment, you can see Blake's handcuff and spare magazine holder. The magazine in the holder is not a Glock magazine.
In Batman Begins Lucius Fox says about the Batsuit: "This sucker will stop a knife." In "The Dark Knight Rises", Batman gets stabbed. However, in The Dark Knight, Fox gives Batman a new suit that makes him more agile but also "more vulnerable to knives and gunfire". If Batman kept his old suit, it's likely that the knife would've been less effective.
Throughout the movie, the Gotham City Police Department uniform and cars show GPD and GCPD inconsistently. It is not uncommon for police forces to change vehicle liveries and/or styles of their uniforms every once in a while. New vehicles would be added to their fleet and given the new livery - to change every other older vehicle in the fleet to the same new livery would not be cost-effective.
(at around 1h 45 mins) Midway through the movie, there is an aerial shot of a Tumbler (Batmobile) being slowly driven down a snow-covered street. The vehicle features a set of 4 rear wheels, yet only a single set of tire tracks are left in its path. This is due to the tread on the tires. The tracks are being left by the smoother, treaded front tires. Which can be seen picking up snow as the vehicle moves forward. The rear tires are not picking up snow because the tread is deeper, like that found on a more aggressive off road tire.
(at around 55 mins) When Batman and Selina are on the roof, Los Angeles landmarks are visible including the U.S. Bank Tower and One Wilshire. This is not an error, as many landmarks that are obviously from other cities (Manhattan island, Brooklyn Bridge, Heinz Field, Sears Tower, etc.) are present throughout the trilogy to keep ambiguous which city Gotham represents.
(at around 55 mins) After saving Selina from Bane's men on the rooftop Batman parks the Bat in the cave followed by the scene where Alfred tells him about the letter and then leaves. When Bruce Wayne returns from the prison and saves Fox with the help of Selina and Fox asks where he had parked the Bat, it is parked on the rooftop of a building (at around 2h 5 mins) rather than where he had left it, in the cave. Batman most likely flew it onto the rooftop on his way to meet Selina in the subway, even though we don't see him travel there.
(at around 11 mins) At the start of the film, when Selina Kyle inspects Bruce Wayne's desk, a picture of Rachel can be seen next to a picture of Bruce's parents. Later on (at around 1h 8 mins) Miranda Tate inspects a similar set of photos after Bruce broke into his own house. The second set of photos were different as they were not in Bruce's bedroom but more likely a downstairs lounge area.
(at around 1h 17 mins) Selina Kyle operates under the assumption that obtaining the "clean slate" device will erase her criminal record. Regardless of this, Selina fails to initially take into account that while the Clean Slate would theoretically erase her electronic criminal records, it will not erase Selina's overflowing binder of hard copy files the Gotham City police Department has amassed over the years, as presented to her by Blake at the airport.
Unless the Bat had taken the bomb over the horizon, the blast effect would have impacted at least the coastal fringes of city, if not further inland. A blast large and close enough to be seen in the city would be large enough to cause extensive damage to that city.
A sewer system has THOUSANDS of drains, manholes and gratings across a major city. To believe that any collection of armed mercenaries could keep several thousand police officers underground in a sewer for months at a time is inconceivable.
Gotham City is essentially a major urban area the size and population of at least Chicago. However, there were apparently no county, state or federal law enforcement agents anywhere in the city limits, nor are there any military or National Guard members there as well. The Gotham PD actually should been the LEAST of Bane's concerns as most major cities have hundreds, if not thousands of law enforcement and military elements in or near them.
(at around 22 mins) During the shootout in the alley between the cops and terrorists after Selina meets Stryver in the bar, one of the SWAT team appears to already have a bullet hole in the back of his flak jacket exactly where the sniper shoots him moments later.
(at around 2h 5 mins) When Batman saves Blake from the ambush by Christopher Judge's character, he fights the henchmen. The guy to the very left never even encounters him yet is flown backwards and falls down as if he was attacked by Batman.
(at around 53 mins) When Selina is fighting the goons on the roof and Batman comes to help her, her shoes go from being high heels to flats (especially noticeable when she runs for the Bat) - despite clearly making a point of her shoes being heels in the prior scene with Daggett.
The seasons throughout the film are portrayed inconsistently even with the passage of time. This is evidenced via leaf foliage shown inconsistently throughout the film. For example, during the "winter" scenes on the isolated Gotham, many streets have a dusting of "snow" only to have trees with green leaves visible a block away.
(at around 50 mins) In the first scene featuring the Bat, shadows cast by the Bat's supporting cables can be seen moving on the building in the background. These are most visible in the shot of the policeman's hat being blown off. The wires themselves were digitally removed in post production.
(at around 2h 10 mins) Chalk markings "S/T" could be seen in a shot of the police-thug battle in Wall Street. They were believed to be the markings for the police actors to know where to standby before film rolled.
The goof items below may give away important plot points.
(at around 2h) When Bruce returns to Gotham and meets Selina to give her the Clean Slate, when Bruce is speaking and the camera angle changes a couple of times to behind his right shoulder, his lips are not moving.
(at around 1h 29 mins) During the Football Field explosion sequence, the grass goes from a dull brownish green turf before and during the explosion, to a deep lustrous green turf as Bane walks onto what remains of the field.
(at around 1h 50 mins) When Captain Jones turns to his last man, the hallway in front of him is empty. After the last man is killed and the camera switches back over to Jones, the hallway has several bodies in it despite neither Jones nor his last man shooting between shots.
(at around 2h 30 mins) When Batman flies the bomb to open sea and it goes off, the mushroom cloud is lit from the left-hand side (supposedly from West as the sun sets). This means daylight is supposed to fade during following shots. However in a subsequent shot, daylight is brighter, with the mushroom cloud now lit from its right-hand side.
(at around 2h 35 mins) The final scene of the movie shows Alfred sitting in a café in Florence reading the Italian newspaper "La Repubblica". The newspaper is printed in black and white. That's the way La Repubblica is printed in foreign countries. In Italy and therefore also in Florence it can only be bought printed in color. This would be very obvious in this take because on the left and on the right of the big "La Repubblica" top line is always placed colored advertisement.
It is not possible for Fox to know in which hour or minute exactly the nuclear device is going to explode as he didn't know at what time it was armed and countdown began. However, he was there when the reactor was activated, so he'd have a fairly good guess.
(at around 2h 35 mins) At the end, when they found out its program was tampered, Fox was running analysis on "The Bat", which would have been obliterated inside a nuclear explosion. This Bat however, is the original model, light blue, shown to Bruce by Fox during their meeting. (at around 38 mins) Fox explains that "it does come in black," indicating that it is quite possible he had more than one of these vehicles in his possession at Applied Sciences at that time. Considering this, any software patch used by Bruce to fix the autopilot issue would have transferred onto all of the models, making it quite possible that the vehicle seen at the end is not the one piloted by Batman during the film.
(at around 1h 14 mins) Early on in the film Bane makes a big point about how he was born in the dark and never saw light till he was a grown man. Later when we see the pit it is not only well lit but we get another speech about how the view of the sky is a key part of the prison's design. He never said he was born in the prison. Simply in the dark.
(at around 26 mins) After James Gordon is injured after meeting Bane the first time, John Blake visits Bruce Wayne and tells him that James Gordon was babbling about an underground army and a masked man called Bane. Bane never reveals his name during James Gordon's visit in the sewers. However both the CIA man at the beginning and Alfred's briefing indicate that Bane is a fairly well-known terrorist and mercenary and as the Police Commissioner of a major US city it's quite likely that Gordon would have access to counter-terror reports and briefs and would recognize Bane from them.
(at around 1h 15 mins) After Bane takes the cowl off of Batman you can see Bruce's hair and then we see Bane toss the cowl down. Moments later we see Bane's men dragging Batman but his cowl happens to be on his head and with no harm done. This is because only the front part of the cowl is ripped off, leaving the back intact and you don't see his face as he is dragged away because of shadows hiding it.
(at around 2h 5 mins) 3,000 police officers are trapped underground for 3 months, kept alive by food parcels, yet when they are released, not one of them shows signs of significant beard growth. However, it is possible that they received razors with their food.
Daggett's plan for hijacking Wayne's company could not have happened. Not only would it be fairly evident that Wayne was not on the trading floor that day, the fact that a terrorist had seized control of the Stock Exchange and hacked into their network would have cancelled all trading that occurred that day and called any trades that went through into question.
When Gordon is taken by Bane's men and put on 'trial', it is shown that Bane takes Miranda hostage. However, a later scene shows Bruce meeting Miranda and Fox, neither are hostages. Later still, when he first appears before Gordon, Batman asks where Miranda is, despite seeing her as Bruce Wayne in a previous scene.
(at around 5 mins) Bane's rationale for keeping one of his henchmen in the plane is that "they expect one of us in the wreckage". That mirrors what the CIA agent had said earlier about having filed a flight plan with only one additional passenger. However, he is revealed to have been merely bluffing when he doesn't actually throw the first henchman off the plane, and we can assume that Bane had seen through the ruse when he mentions the oddity of shooting a man before throwing off a plane. In all likeliness, the flight plan did include all additional passengers (who could have been kept around for further interrogation) and Bane should have kept 2 additional decoys on board to maintain the illusion that all perished in the crash.
(at around 1h 29 mins) In the football stadium explosion scene, the camera quickly shifts from a ground view of the stadium collapsing to a helicopter view. The end-zones of the football field change colors when it cuts.
(at around 2h 30 mins) In the final scene, when the bomb is shown ticking closer to zero, smoke is seen emanating from it slowly as if the bomb were stationery. But in fact it is hanging by a wire and carried away into the ocean by The Bat at high speed, so the smoke should travel much faster.
(at around 1h 55 mins) When Bruce Wayne makes his free climb out of the prison, the climbing and belaying ropes are no longer in place, presumably to clean up the shot and enhance the purity of the climb.